the 3000wfr series is a family of compact 25w to 30w, high performance dc/dc converters. these converters are specifically designed to provide the flexibility, power density, and reliability required to fulfill local power needs in applications ranging from telecom switch systems to portable instrumentation. 27 models operate over 2:1 input ranges of 9 to 18, 18 to 36 or 36 to 72 vdc; providing single, dual or triple output combinations of 3.3, 5, 12, 15, 5, 12, 15, 512 and 515 vdc. all models are packaged in compact, low profile 2.0 x 2.0 x 0.4 metal cases. d d e e s s c c r r i i p p t t i i o o n n s s 3000wfr series ? ? 6 6 s s i i d d e e d d c c o o n n t t i i n n u u o o u u s s s s h h i i e e l l d d i i n n g g ? ? r r e e m m o o t t e e o o n n / / o o f f f f c c o o n n t t r r o o l l ? ? w w i i d d e e 2 2 : : 1 1 i i n n p p u u t t v v o o l l t t a a g g e e r r a a n n g g e e ? ? e e f f f f i i c c i i e e n n c c y y t t o o 8 8 5 5 % % ? ? o o u u t t p p u u t t v v o o l l t t a a g g e e t t r r i i m m u u p p t t o o 1 1 0 0 % % f f e e a a t t u u r r e e s s i i n n p p u u t t c c h h a a r r a a c c t t e e r r i i s s t t i i c c s s o o u u t t p p u u t t c c h h a a r r a a c c t t e e r r i i s s t t i i c c s s unit/comments input voltage range 12 vdc input models vdc 24 vdc input models vdc 48 vdc input models vdc remote on / off control supply on 5.5 vdc or open circuit supply off 0 vdc to 0.8 vdc logic referenced to negative input input filter pi filter unit/comments % 1 % 1 % 1 % 1 %; equal output loads mv; equal output loads full load % 2 % 2 % 2 % 2 % 3 % 3 ; equal loads % 3 % 3 ; equal loads mv; p-p, nom.line fl, 20mhz b.w. using 1 f bypass capacitor % of vout continuous, auto- matic recovery s to within1% error band for 50% step load change % per o c min typ max 2 2 5 10 2 100 10% 0.5 0.5 1 5 1 1 1 5 75 1 100 0.01 single, dual, triple output dc/dc converter min 9 18 36 typ 12 24 48 max 18 36 72 g g e e n n e e r r a a l l c c h h a a r r a a c c t t e e r r i i s s t t i i c c s s unit/comments switching frequency khz isolation voltage vdc, 1 minute isolation resistance mohm, 500vdc min 500 1000 typ 300 max output voltage accuracy single & dual outputs triple outputs - primary - auxiliaries output voltage trim voltage balance: dual outputs triple outputs (auxiliaries) minimum load line regulation single outputs dual outputs triple outputs - primary - auxiliaries load regulation single outputs dual outputs triple outputs - primary - auxiliaries ripple/noise 5v outputs 12v and 15v outputs short circuit protection transient recovery time temperature coefficient over voltage protection 1 = output voltage at nominal line & fl 2 = % output voltage measured from min. input line to maximum 3 = output voltage measured from fl to 10% load see model selection guide >> 1 www.make-ps.com e-mail:info@make-ps.com
e e n n v v i i r r o o n n m m e e n n t t a a l l s s p p e e c c i i f f i i c c a a t t i i o o n n s s o o u u t t l l i i n n e e d d r r a a w w i i n n g g p p h h y y s s i i c c a a l l c c h h a a r r a a c c t t e e r r i i s s t t i i c c s s unit/comments 2.0 x 2.0 x 0.4 inches (50.8 x 50.8 x 10.2 mm) coated metal with non- conductive base negative input positive input ul94v-0 case size case material shield connection 12v and 24v input models 48v input models flammability unit/comments o c; ambient o c % humidity; non- condensing free-air convection operating temp. range storage temp. range relative humidity cooling min -25 -55 typ max +71 +105 95 notes: 1. unless otherwise specified dimensions are in inches (mm). tolerances inches mm x.xx = 0.02 x.x = 0.5 x.xxx= 0.010 x.xx = 0.25 2. mounting inserts: 4-40 x .10 (2.5) deep .90 [22.9] 2.00 [50.8] .20 [5.1] typ. .40 [10.2] .40 [10.2] typ. 7 8 6 5 3 4 1 bottom view side view .40 [10.2] .22 [5.6] 2.00 [50.8] .040 (1.0) typ. pin dia. 1.80 [45.72] p p i i n n o o u u t t c c h h a a r r t t pin 1 2 3 4 5 6 7 8 single remote on/off no pin - vin + vin trim - vout + vout no pin dual remote on/off no pin - vin + vin trim - vout common + vout triple remote on/off no pin - vin +vin - aux. out common +5v out + aux. out all specifications are typical at nominal input, nominal load and 25 c unless otherwise specified. external, low esr, 10 microfarad (minimum) capacitor across output is recommended for operation. >> 2 www.make-ps.com e-mail:info@make-ps.com
h h o o w w t t o o o o r r d d e e r r 30 xx s xx wfr - y output voltage h h o o w w t t o o o o r r d d e e r r m m o o d d e e l l s s e e l l e e c c t t i i o o n n c c h h a a r r t t model nominal input voltage (vdc) input voltage range (vdc) no load input current (ma) full load input current (ma) output voltage (vdc) full load output current (ma) efficiency @fl (%) output configuration (s=single, d=dual) wattage rohs complaint model series nominal input voltage 3003s12wfr 3005s12wfr 3012s12wfr 3015s12wfr 3003s24wfr 3005s24wfr 3012s24wfr 3015s24wfr 3003s48wfr 3005s48wfr 3012s48wfr 3015s48wfr 3005d12wfr 3012d12wfr 3015d12wfr 3005d24wfr 3012d24wfr 3015d24wfr 3005d48wfr 3012d48wfr 3015d48wfr 3005/12t12wfr 3005/15t12wfr 3005/12t24wfr 3005/15t24wfr 3005/12t48wfr 3005/15t48wfr 12 12 12 12 24 24 24 24 48 48 48 48 12 12 12 24 24 24 48 48 48 12 12 24 24 48 48 9 - 18 9 - 18 9 - 18 9 - 18 18 - 36 18 - 36 18 - 36 18 - 36 36 - 72 36 - 72 36 - 72 36 - 72 9 - 18 9 - 18 9 - 18 18 - 36 18 - 36 18 - 36 36 - 72 36 - 72 36 - 72 9 - 18 9 - 18 18 - 36 18 - 36 36 - 72 36 - 72 30 30 30 30 30 30 30 30 20 20 20 20 35 35 35 30 303 30 25 25 25 35 35 30 30 25 25 1860 2675 3050 3050 920 1336 1525 1525 460 660 765 765 2675 3050 3050 1336 1470 1470 660 735 735 2640 2640 1320 1320 655 655 3.3 5.0 12.0 15.0 3.3 5.0 12.0 15.0 3.3 5.0 12.0 15.0 5 12 15 5 12 15 5 12 15 5/12 5/15 5/12 5/15 5/12 5/15 5000 5000 2500 2000 5000 5000 2500 2000 5000 5000 2500 2000 2500 1250 1000 2500 1250 1000 2500 1250 1000 3500/310 3500/250 3500/310 3500/250 3500/310 3500/250 74 78 82 82 75 79 82 82 75 79 82 82 78 82 82 79 85 85 79 85 85 79 79 80 80 80 80 >> 3 30 xx / xx t xx wfr - y main output voltage aux. main output voltage output configuration (t=triple) wattage rohs complaint model series nominal input voltage www.make-ps.com e-mail:info@make-ps.com
|
